Product ID:FP003, PREP TONE
MSDS Date:07/10/1989
FSC:6850
NIIN:00N029919
MSDS Number: BPDGL

INLAND TECHNOLOGY INC

2612 PACIFIC HIGHWAY EAST
TACOMA, WA 98424
US

Emergency Phone: 800-552-3100

Info Phone: 206-922-8932

Cage: 0K209

ETHANOL, 2-BUTOXY-; (GLYCOL ETHER EB)

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: 6%

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9293

SILICIC ACID (H*2SIO*3), DISODIUM SALT; (SODIUM

CAS: 6834-92-0

RTECS: VV9275000

OSHA PEL 2 MG/M3

OR CLAY ETC. AND SHOVELED INTO CONTAINERS.

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:(ACUTE)EYES: OVEREXP CAN CAUSE SEV
IRRIT, REDNESS, TEARING, & BLURRED VISION. SODIUM METASILICATE IS
CORR TO EYES. SKIN: PRLNGD/RPTD CONT CAN CAUSE IRRIT, DEFAT & DERM.
CAN BE ABSORBED IN TOX AMTS, ES PEC FROM PRLNGD/RPTD EXPOS. INHAL:
EXCESSIVE INHAL OF VAPS CAN CAUSE NASAL & RESP IRRIT, CNS EFTS INCL
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: DIZZ,WEAK, FATIGUE, NAUS, HDCH & POSS
UNCON, & EVEN DEATH. INGEST: CAN CAUSE GI IRRIT, NAUS, VOMIT &
DIARR. (CHRONIC) OVEREXP TO EB GLYCOL ETHER HAS APPARENTLY BEEN
FOUND TO CAUSE THESE EFTS IN LAB ANIMALS: LIVER ABNORM, ANEMIA,
KIDNEY DMG, LUNG DMG, & BLOOD ABNORMALITIES. ANIMAL STUDIES CLEARLY
(SUPP DATA)
Medical Cond Aggravated by Exposure:HEADACHES, SKIN & EYE IRRITATION.

First Aid:SKIN: THORO WASH EXPOSED AREA WITH SOAP AND WATER. REMOVE
CONTAM CLOTHING AND LAUNDER BEFORE RE-USE. EYES: FLUSH WITH LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MIN, LIFTING UPPER AND LOWER LIDS
OCCASIONA LLY, GET MEDICAL ATTENTION. INGESTION: IMMEDIATELY DRINK
TWO GLASSES OF WATER AND CALL PHYS. INHALATION: REMOVE INDIVIDUAL
TO FRESH AIR, IF BREATHING BECOMES DIFFICULT GIVE ARTF RESP. SEEK
MED ATTN.

Extinguishing Media:CO2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:SML: ABSORB LIQ ON PAPER, VERMICULITE, FLOOR
ABSORB/OTHER ABSORB & TRANSFER TO HOOD. LRG: ELIMINATE ALL IGNIT
SOURCES, PERSONS NOT WEARING PROT EQUIP SHD BE EXCLUDED FROM SPILL
AREA, OR UNTIL CLEAN-UP HAS BEEN COMPLETED. STOP SPILL AT (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP CONTAINER CLOSED AND AVOID
FREEZING.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ ALL LABELS AND
CAUTIONS BEFORE USE.

Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV'S.
Protective Gloves:NON-ABSORBENT GLOVES.
Eye Protection:CHEM WORK GOG & FULL LGTH FACESHLD
Other Protective Equipment:WEAR PROT CLTHG-NON ABSORBENTS. READ ALL
CAUTIONS AND LABELS BEFORE USE. EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:WEAR CLEAN PROTECTIVE EQUIPMENT.
Supplemental Safety and Health
EFTS OF OVEREXP: DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON CNS,
HEMATOPOIETIC TISS, BLOOD, KIDNEYS & LIVER, ASSOC W/ ADMIN OF EGBE.
(EXTRACTED FROM DHHS (NIOSH) PUBLICATION NO. 90-118) . SPILL P ROC:
SOURCE, DIKE AREA OF SPILL TO PVNTSPREADING, PUMP LIQ TO SALVAGE
TANK. REMAINING LIQ MAY BE TAKEN UP W/SAND (ING 3

HCC:C1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:25
Spec Gravity:1.02 (H2O=1)
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:100%
Appearance and Odor:RED WITH CELLOSOLVE ODOR.
Percent Volatiles by Volume:90

Stability Indicator/Materials to Avoid:YES
CONCENTRATE MINERAL ACIDS AND STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEATING OR FREEZING.
Hazardous Decomposition Products:NOT APPLICABLE.

Waste Disposal Methods:CONTACT FEDERAL, STATE, COUNTY OR LOCAL
ENVIRONMENTAL REGULATIONS FOR GUIDANCE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.